广西顶博发电机组制造

13667715899

添加微信好友了解产品w13667715899

当前位置:首页 > 技术支持

又到暴雨潮湿季节了,广西顶博发电机组制造进水该怎么办?

2021-07-31
来源: 原创
10631
当多雨或鼓风机季来永久性,有将发生雷暴、雷暴等当然灾难的影响力,因柴油车发起机并网发交流接触器组通信机房基本上是在地埋式室和1楼将会被水淹,要并网发交流接触器组储藏防护栏疏忽和某个主观原因水有将从烟管流入发起机缸体。当柴油车发起机并网发交流接触器组漏液时,假如在运行请即时熄火,并利用有必要的的的具体措施,段开外供电及蓄微型锂电池接驳线,也诊断不同的位置的漏液现象。


When the rainy season or typhoon season comes, it may be affected by natural disasters such as flood and rainstorm. Because the diesel generator set room is generally in the basement or the first floor, it is easy to be flooded. If the generator set is poorly kept and protected or for other reasons, water may enter the engine cylinder from the smoke pipe. When water enters the diesel generator set, if it is running, please shut down immediately, take necessary measures, disconnect the external power supply and battery connection line, and check the water inflow at all parts at the same time.


广西顶博发电机组制造机房


检查广西顶博发电机组制造进水常见问题

1、诊断排气管压缩空气管(排风管管低点处或消音器)的雨排建筑构件有没有滴水出排。Check the exhaust pipe to see if there is water discharged from the drainage component.


2、检验新鲜空气过滤芯塑料外壳会不会有肾积水,过滤芯会不会被水浸渍。Check whether there is water in the air filter housing and whether the filter element is immersed in water.


3、查验电站机外层下端有没有有积水情况。Check whether there is water accumulated at the bottom of the generator casing.


4、全面检查蒸发器器、散热器风扇、轴承等转动安全装置会不短路。Check radiator, fan, coupling for blockage.


5、异常能不有机化学油、燃料或水的渗漏。Whether there is leakage of organic oil, fuel or water from the outside.


6、卸开拐臂室盖,了解需不需要有渗水。全面检查火力发无刷电机电机绕线绝缘性/环境破坏前提。Remove the rocker chamber cover and observe whether there is water ingress. Check the insulation and ontamination of the generator windings.


7、测量保持三极管和打印输出三极管的绝缘电阻。测量保持显示屏摸块、各汽车仪表盘、告警设备、开启打开。Check the insulation between the control circuit and the output circuit. Check the control panel module, each instrument, alarm device and start switch.


关注:任何时候并不能让水侵扰热车机的焚烧室!Note: Never let water enter the combustion chamber of the engine!


手表进水处置技术柴油发动机来发减速设备接触不良后的加工处理无法:Treatment  after water enter the generator:


当来判断重油生产发高压电空气能空气能热泵打火机的丙烷冷却系统无进水并且没有及时正确地处理,耐压符合满足要求满足要求时,可开机时重油生产发高压电空气能空气能热泵。在开机时时要重视下述疑问:When confirm there is no water in the combustion chamber  and the insulation meets the requirements,can start the generator. Pay attention to the following issues when starting:


1、在开始进步行那些检验,还包括排卸柴油箱污水。电力工程系统的日益上电,考察有没有异样。Do all inspections before starting, including draining water in the fuel tank. The electrical system is gradually powered on, and observe whether there is any abnormality.


2、维持开始启驱力的期限不会超越秒钟钟。若启驱力不会自燃,则定期检查气油管道阀门及电气开关电路,两三小时后再度开始。Start the engine continuously shall not exceed 30 seconds. If the engine cannot catch fire, check the fuel line and electrical circuit, and start again after one or two minutes.


3、查启行为配音有无有越来越,有无有腥臭味。查电力设备仪表板的信息体现 、夜晶信息体现 屏有无断屏或信息体现 不清。


Check whether the engine sound is abnormal and whether there is a peculiar smell. Check whether the display of the electrical instrument and the LCD screen are broken or unclear.


4、重视观测打着机汽车机油负荷和水摄氏度,假如汽压或摄氏度不具有合技术水平制约,应闭合打着机。断电后,檢查做次打着机汽车机油平米。Closely observe the oil pressure and water temperature. If the oil pressure or temperature does not meet the technical specifications, the engine should be shut down. After stopping, check the oil level.


当决定发起机或者浸水、带发主轴交流接触器绝缘性对不上合要时,谨防强行维修费,应谋求带发主轴交流接触器组工厂的专科新技术人数的可以帮助。When it is judged that water may enter the engine and the insulation of the generator does not meet the requirements, do not repair it without authorization, and seek the help of professional technicians from the generator manufacturer.


大暴雨/太潮条件,汽油生产柴油机发电机的组动用准备原则Key points for unit operation in rainstorm / humid environment


1、摆放生态环境规定1. Placement environment requirements(1)室外摆放运行的机柜,需提前做好防水遮阳的措施,手机配置防水遮阳棚、靜音箱等;


Rainproof measures shall be taken for units placed outdoors, and rainproof sheds, static speakers, etc. shall be equipped;


(2)空气能硬壳须有安全可靠的保護跨接,对就必须有弱酸性点就直接跨接的生产发电动机,则就必须由专业技术职工对其进行弱酸性跨接;The shell of the unit must be reliably grounded. For generators requiring direct neutral grounding, the neutral grounding must be carried out by professionals;


(3)打雷频发地方采用仪器,请硬件配置防雷裝置。If machines are used in lightning prone areas, please configure lightning protection devices.


(4)请最好不要将空调机组放上于地貌较低,基础不牢(和泥土屋面)易渗漏的地方;Please do not place the unit in a place with low terrain, weak foundation (soil ground) and easy to accumulate water;


(5)放在下水道室的使用的机气,需干好下水道室排出污水、防水上班。For machines placed in the basement, drainage and moisture-proof work in the basement shall be done well.
介绍好的文章
柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家